Re: Re: [pdx-biodiesel] wash tank pump failure
Zac Imboden <[email protected]> Sun, 24 Jun 2007 14:37:55 -0700
| Newsgroups | gmane.org.clubs.gobiodiesel.mixmasters |
|---|---|
| Message-ID | <[email protected]> |
--===============1508637321== Content-Type: multipart/alternative; boundary=Apple-Mail-8-402929333 --Apple-Mail-8-402929333 Content-Transfer-Encoding: 7bit Content-Type: text/plain; charset=US-ASCII; delsp=yes; format=flowed Sounds good. Thanks for all your hard work. On Jun 24, 2007, at 2:07 PM, George M. Peters wrote: > Zac and Felix, > > Will check it out......space may not permit now, but when we raise > that tank and fit the second wash tank, we may be able to put PVC > unions on both tanks. I do not have time to do PVC re-piping on > Monday on the wash tank as it is currently piped because the system > must be running for planned activities Tue PM. If Felix can bring > the supplies we need and help do the work, that could work. > Otherwise, I will use plastic camlock. > > George > > ----- Original Message ---- > From: Zac Imboden <[email protected]> > To: General Biodiesel discussion <[email protected]> > Cc: GoBiodiesel Mixmasters <[email protected]> > Sent: Sunday, June 24, 2007 1:42:34 PM > Subject: [mixmasters] Re: [pdx-biodiesel] wash tank pump failure > > George, > > I talked to Felix about the pump repair. He put together the wash > system. He recommends that you use PVC unions to connect the pump > rather than camlock connectors, because the camlocks will eventually > leak. If you can pick some of those up instead, it would probably be > better. > > On Jun 23, 2007, at 8:56 PM, George M. Peters wrote: > > > > > > > ----- Original Message ---- > > From: George M. Peters <gmp402001-/[email protected]> > > To: springnutz-/[email protected] > > Sent: Saturday, June 23, 2007 8:53:11 PM > > Subject: Re: [pdx-biodiesel] wash tank pump failure > > > > Zan. > > Replacement pump is wired and half-piped with flexible tubing (to > > permit future repairs) > > Kevin and I got to that point after removing the defective pump > > without cutting the PVC. Hope to get the fittings for the pump > > when the supplier opens Mon.....should be able to complete by noon > > 6/25. > > George > > > > > > ----- Original Message ---- > > From: Zan Alford <springnutz-/[email protected]> > > To: [email protected] > > Sent: Saturday, June 23, 2007 7:50:27 PM > > Subject: [pdx-biodiesel] wash tank pump failure > > > > Hello all > > Well George and myself went down to the site this morning and > > drained the water off > > the wash tote and replaced it with some clean hot water and ran a > > good cycle of wash on it it looks great. however at the end of the > > cycle the pump or pump motor started making loud growling noise > > like the bearings going out or something. I was not able to look > > at it as It happened just as we were getting ready to leave and I > > had no more time to spare. But I wanted to give a heads up so if > > any one has time they can work on it or replace it with one of the > > new ones in the con ex. I left a entry in the site log on what we > > did also. > > cheers > > Zan > > > > > > > > > > --------------------------------- > > No need to miss a message. Get email on-the-go > > with Yahoo! Mail for Mobile. Get started. > > _______________________________________________ > > pdx-biodiesel mailing list > > [email protected] > > http://lists.gobiodiesel.org/mailman/listinfo/pdx-biodiesel > > > > > > > > > > > > > > > > Choose the right car based on your needs. > > Check out Yahoo! Autos new Car Finder tool. > > > > > > > > > > > > > > > > > ______________________________________________________________________ > > ______________ > > Building a website is a piece of cake. Yahoo! Small Business gives > > you all the tools to get online. > > http://smallbusiness.yahoo.com/webhosting > > _______________________________________________ > > pdx-biodiesel mailing list > > [email protected] > > http://lists.gobiodiesel.org/mailman/listinfo/pdx-biodiesel > > > > > > -------------------------------------------------------------- > Zac Imboden > [email protected] > 6355 North Burrage Ave > Portland, OR > 97217 > 971-563-2477 > > > > > _______________________________________________ > mixmasters mailing list > [email protected] > http://lists.gobiodiesel.org/mailman/listinfo/mixmasters > > > You snooze, you lose. Get messages ASAP with AutoCheck > in the all-new Yahoo! Mail Beta. > _______________________________________________ > mixmasters mailing list > [email protected] > http://lists.gobiodiesel.org/mailman/listinfo/mixmasters -------------------------------------------------------------- Zac Imboden [email protected] 6355 North Burrage Ave Portland, OR 97217 971-563-2477 --Apple-Mail-8-402929333 Content-Transfer-Encoding: quoted-printable Content-Type: text/html; charset=ISO-8859-1 <HTML><BODY style=3D"word-wrap: break-word; -khtml-nbsp-mode: space; = -khtml-line-break: after-white-space; ">Sounds good. Thanks for all your = hard work.<DIV><BR><DIV><DIV>On Jun 24, 2007, at 2:07 PM, George M. = Peters wrote:</DIV><BR class=3D"Apple-interchange-newline"><BLOCKQUOTE = type=3D"cite"><DIV style=3D"font-family:times new roman, new york, = times, serif;font-size:12pt"><DIV style=3D"font-family: times new = roman,new york,times,serif; font-size: 12pt;">Zac and Felix,<BR><BR>Will = check it out......space may not permit now, but when we raise that tank = and fit the second wash tank, we may be able to put PVC unions on both = tanks.=A0 I do not have time to do PVC re-piping on Monday on the wash = tank as it is currently piped because the system must be running for = planned activities Tue PM.=A0 If Felix can bring the supplies we need = and help do the work, that could work.=A0 Otherwise, I will use plastic = camlock.<BR><BR>George<BR><BR><DIV style=3D"font-family: times new = roman,new york,times,serif; font-size: 12pt;">----- Original Message = ----<BR>From: Zac Imboden <<A = href=3D"mailto:[email protected]">[email protected]</A>>= ;<BR>To: General Biodiesel discussion <<A = href=3D"mailto:[email protected]">[email protected]= biodiesel.org</A>><BR>Cc: GoBiodiesel Mixmasters <<A = href=3D"mailto:[email protected]">[email protected]= com</A>><BR>Sent: Sunday, June 24, 2007 1:42:34 PM<BR>Subject: = [mixmasters] Re: [pdx-biodiesel] wash tank pump = failure<BR><BR><DIV>George,<BR><BR>I talked to Felix about the pump = repair. He put together the wash=A0=A0<BR>system. He recommends that you = use PVC unions to connect the pump=A0=A0<BR>rather than camlock = connectors, because the camlocks will eventually=A0=A0<BR>leak. If you = can pick some of those up instead, it would probably = be=A0=A0<BR>better.<BR><BR>On Jun 23, 2007, at 8:56 PM, George M. Peters = wrote:<BR><BR>><BR>><BR>> ----- Original Message ----<BR>> = From: George M. Peters <<A = href=3D"mailto:gmp402001-/[email protected]">gmp402001-/[email protected]</A>><BR>> = To: <A = href=3D"mailto:springnutz-/[email protected]">springnutz-/[email protected]</A><BR>> = Sent: Saturday, June 23, 2007 8:53:11 PM<BR>> Subject: Re: = [pdx-biodiesel] wash tank pump failure<BR>><BR>> Zan.<BR>> = Replacement pump is wired and half-piped with flexible tubing = (to=A0=A0<BR>> permit future repairs)<BR>> Kevin and I got to that = point after removing the defective pump=A0=A0<BR>> without cutting = the PVC.=A0=A0Hope to get the fittings for the pump=A0=A0<BR>> when = the supplier opens Mon.....should be able to complete by noon=A0=A0<BR>>= ; 6/25.<BR>> George<BR>><BR>><BR>> ----- Original Message = ----<BR>> From: Zan Alford <<A = href=3D"mailto:springnutz-/[email protected]">springnutz-/[email protected]</A>><BR>> = To: <A = href=3D"mailto:[email protected]">[email protected]= biodiesel.org</A><BR>> Sent: Saturday, June 23, 2007 7:50:27 = PM<BR>> Subject: [pdx-biodiesel] wash tank pump = failure<BR>><BR>> Hello all<BR>>=A0=A0 Well George and myself = went down to the site this morning and=A0=A0<BR>> drained the water = off<BR>>=A0=A0the wash tote and replaced it with some clean hot water = and ran a=A0=A0<BR>> good cycle of wash on it it looks great. however = at the end of the=A0=A0<BR>> cycle the pump or pump motor started = making loud=A0=A0growling noise=A0=A0<BR>> like the bearings=A0=A0going= out or something. I was not able to look=A0=A0<BR>> at it as It = happened just as we were getting ready to leave and I=A0=A0<BR>> had = no more time=A0=A0to spare. But I wanted to give a heads up so = if=A0=A0<BR>> any one has time they can work on it or replace it with = one of the=A0=A0<BR>> new ones in the con ex.=A0=A0I left a entry in = the site log on what we=A0=A0<BR>> did also.<BR>>=A0=A0 = cheers<BR>>=A0=A0 Zan<BR>><BR>><BR>><BR>><BR>> = ---------------------------------<BR>> No need to miss a message. Get = email on-the-go<BR>> with Yahoo! Mail for Mobile. Get = started.<BR>> _______________________________________________<BR>> = pdx-biodiesel mailing list<BR>> <A = href=3D"mailto:[email protected]">[email protected]= biodiesel.org</A><BR>> <A target=3D"_blank" = href=3D"http://lists.gobiodiesel.org/mailman/listinfo/pdx-biodiesel">http:= //lists.gobiodiesel.org/mailman/listinfo/pdx-biodiesel</A><BR>><BR>>= <BR>><BR>><BR>><BR>><BR>><BR>>=A0=A0=A0=A0=A0=A0 = Choose the right car based on your needs.<BR>> Check out Yahoo! Autos = new Car Finder = tool.<BR>><BR>><BR>><BR>><BR>><BR>><BR>><BR>> = ______________________________________________________________________ = <BR>> ______________<BR>> Building a website is a piece of cake. = Yahoo! Small Business gives=A0=A0<BR>> you all the tools to get = online.<BR>> <A target=3D"_blank" = href=3D"http://smallbusiness.yahoo.com/webhosting">http://smallbusiness.ya= hoo.com/webhosting</A><BR>> = _______________________________________________<BR>> pdx-biodiesel = mailing list<BR>> <A = href=3D"mailto:[email protected]">[email protected]= biodiesel.org</A><BR>> <A target=3D"_blank" = href=3D"http://lists.gobiodiesel.org/mailman/listinfo/pdx-biodiesel">http:= //lists.gobiodiesel.org/mailman/listinfo/pdx-biodiesel</A><BR>><BR>>= <BR><BR>--------------------------------------------------------------<BR>= Zac Imboden<BR><A = href=3D"mailto:[email protected]">[email protected]</A><BR= >6355 North Burrage Ave<BR>Portland, = OR<BR>97217<BR>971-563-2477<BR><BR><BR><BR><BR>___________________________= ____________________<BR>mixmasters mailing = list<BR>[email protected]<BR><A target=3D"_blank" = href=3D"http://lists.gobiodiesel.org/mailman/listinfo/mixmasters">http://l= ists.gobiodiesel.org/mailman/listinfo/mixmasters</A><BR></DIV></DIV><BR></= DIV></DIV><BR> <HR size=3D"1">You snooze, you lose. <A = href=3D"http://us.rd.yahoo.com/evt=3D47959/*http://advision.webevents.yaho= o.com/mailbeta/newmail_html.html">Get messages ASAP with = AutoCheck</A><BR> in the all-new Yahoo! Mail Beta. <DIV = style=3D"margin-top: 0px; margin-right: 0px; margin-bottom: 0px; = margin-left: 0px; = ">_______________________________________________</DIV><DIV = style=3D"margin-top: 0px; margin-right: 0px; margin-bottom: 0px; = margin-left: 0px; ">mixmasters mailing list</DIV><DIV style=3D"margin-top:= 0px; margin-right: 0px; margin-bottom: 0px; margin-left: 0px; "><A = href=3D"mailto:[email protected]">[email protected]= com</A></DIV><DIV style=3D"margin-top: 0px; margin-right: 0px; = margin-bottom: 0px; margin-left: 0px; "><A = href=3D"http://lists.gobiodiesel.org/mailman/listinfo/mixmasters">http://l= ists.gobiodiesel.org/mailman/listinfo/mixmasters</A></DIV> = </BLOCKQUOTE></DIV><BR><DIV> <SPAN class=3D"Apple-style-span" = style=3D"border-collapse: separate; border-spacing: 0px 0px; color: = rgb(0, 0, 0); font-family: Helvetica; font-size: 12px; font-style: = normal; font-variant: normal; font-weight: normal; letter-spacing: = normal; line-height: normal; text-align: auto; = -khtml-text-decorations-in-effect: none; text-indent: 0px; = -apple-text-size-adjust: auto; text-transform: none; orphans: 2; = white-space: normal; widows: 2; word-spacing: 0px; "><SPAN = class=3D"Apple-style-span" style=3D"border-collapse: separate; = border-spacing: 0px 0px; color: rgb(0, 0, 0); font-family: Helvetica; = font-size: 12px; font-style: normal; font-variant: normal; font-weight: = normal; letter-spacing: normal; line-height: normal; text-align: auto; = -khtml-text-decorations-in-effect: none; text-indent: 0px; = -apple-text-size-adjust: auto; text-transform: none; orphans: 2; = white-space: normal; widows: 2; word-spacing: 0px; "><SPAN = class=3D"Apple-style-span" style=3D"border-collapse: separate; = border-spacing: 0px 0px; color: rgb(0, 0, 0); font-family: Helvetica; = font-size: 12px; font-style: normal; font-variant: normal; font-weight: = normal; letter-spacing: normal; line-height: normal; text-align: auto; = -khtml-text-decorations-in-effect: none; text-indent: 0px; = -apple-text-size-adjust: auto; text-transform: none; orphans: 2; = white-space: normal; widows: 2; word-spacing: 0px; "><SPAN = class=3D"Apple-style-span" style=3D"border-collapse: separate; = border-spacing: 0px 0px; color: rgb(0, 0, 0); font-family: Helvetica; = font-size: 12px; font-style: normal; font-variant: normal; font-weight: = normal; letter-spacing: normal; line-height: normal; text-align: auto; = -khtml-text-decorations-in-effect: none; text-indent: 0px; = -apple-text-size-adjust: auto; text-transform: none; orphans: 2; = white-space: normal; widows: 2; word-spacing: 0px; = "><DIV>--------------------------------------------------------------</DIV= ><DIV>Zac Imboden</DIV><DIV><A = href=3D"mailto:[email protected]">[email protected]</A></D= IV><DIV>6355 North Burrage Ave</DIV><DIV>Portland, = OR</DIV><DIV>97217</DIV><DIV>971-563-2477</DIV><DIV><BR = class=3D"khtml-block-placeholder"></DIV><DIV><BR = class=3D"khtml-block-placeholder"></DIV></SPAN><BR = class=3D"Apple-interchange-newline"></SPAN></SPAN></SPAN> = </DIV><BR></DIV></BODY></HTML>= --Apple-Mail-8-402929333-- --===============1508637321== Content-Type: text/plain; charset="us-ascii" MIME-Version: 1.0 Content-Transfer-Encoding: 7bit Content-Disposition: inline _______________________________________________ mixmasters mailing list [email protected] http://lists.gobiodiesel.org/mailman/listinfo/mixmasters --===============1508637321==--